８吨洒水车气缸窜气问题解决方法

８吨洒水车气缸窜气问题解决方法

在我们生活中是尤为重要的环卫车辆，它每天忙碌的帮我们创造美好的生活环境，给我们生活在带来了很大的改善。却没有人爱惜它，其实环卫垃圾车也是需要保养的，这样做可以提高使用寿命，让它更好的为您工作。下面就由小编为大家讲述造成环卫洒水车气缸窜气的原因：
In our life is particularly important for the sanitation vehicles, it is busy every day to help us to create a better living environment, to give us a lot of improvement in life. But no one care about it, in fact, sanitation garbage truck is also need maintenance, so that can improve the service life, so it is better for you to work. The following is a small series to tell you about the cause of sanitation garbage truck cylinder gas:
造成洒水车气缸窜气现象的原因有以下两点：
There are two reasons for the phenomenon of the gas cylinder of the garbage truck:
一、自然原因。随着洒水车行驶里程的增多，活塞与气缸之间的磨损逐渐增大，当这种磨损增大到一定程度时，气缸窜气就会开始，随之烧机油现象就会产生。气门油封损坏时，将使烧机油现象更加明显。
First, the natural causes. With the increase of the mileage of the garbage truck, the wear between the piston and the cylinder gradually increased, when the wear and tear increased to a certain extent, the cylinder will begin to gas channeling, along with burning oil phenomenon will be generated. When the valve oil seal is damaged, it will cause the burning oil phenomenon more obvious.
二、维护不当。
Two, improper maintenance.
1、按规定里程保养发动机，将延长发动机的使用寿命。反之，甚至超里程而不保(即拖保)。机油过脏，机油中杂质就会加速发动机气缸磨损。
1, according to the provisions of mileage maintenance engine, will extend the engine life. On the other hand, even beyond the mileage and not guaranteed (that is, the drag). Oil is dirty, impurities in the oil will accelerate the engine cylinder wear.
2、机油添加量过多。
2, too much oil to add.
3、空滤芯、机滤芯、机油等选用不当，进入气缸的气体杂质不能得到很好净化，各种灰尘颗粒进入气缸，加速气缸磨损。机滤芯的质量差，起不到过滤机油中杂志的作用。假冒机油或是所用机油与使用车辆的机油级别不符，这样，将不能在发动机各磨擦表面形成良好油膜，重者拉缸、轻者窜气。
3, air filter, filter, oil and other improper selection, into the cylinder of the gas impurities can not be very good purification, all kinds of dust particles into the cylinder, accelerate the cylinder wear. The quality of the filter core is poor, and the function of the magazine in the filter oil is not played. Fake oil or the oil level of the oil and the use of vehicles does not match. In this way, will not in the engine of the friction surface formation good oil film, the person that weigh the cylinder, the lighter gas channeling.
4、点火时间过早或过晚。过早或过晚会产生暴震，使发动机温度提高，严重时会使活塞脱顶，缸体报废。它的初期会出现严重缸体窜气烧机油。
4, the ignition time is too early or too late. Too early or too late to produce violent shock, so that the engine temperature increase, serious when the piston off the top, cylinder block. It will appear in the early stage of severe cylinder gas burning oil.
5、冷却系中水箱内污垢过多。散热器及冷凝器过脏，降低通风散热能力，使发动机正常工作温度提高。由于温度过高，润滑油在磨擦时产生的油膜质量下降，气缸磨损加剧。
5, the cooling system in the tank inside the dirt too much. Radiator and condenser are dirty, reduce the ventilation and heat capacity, so that the normal operating temperature of the engine is increased. As the temperature is too high, the oil film quality of lubricating oil is decreased, and the cylinder wear is intensified.
因此，除了随车辆里程增多自然磨损而产生窜气和烧机油外，积极保养，合理使用垃圾车是能够避免气缸窜气现象的早期到来及延长环卫垃圾车的使用寿命的。
Therefore, in addition to with the vehicle mileage increased natural wear and tear and gas channeling and oil burning outside, maintain a positive, rational use of garbage truck is able to avoid the cylinder gas channeling phenomenon of early arrival and prolong the service life of the sanitation garbage truck.
我公司销售生产各种专用车：勾臂垃圾车、对接垃圾车、压缩垃圾车、吸粪车、摆臂垃圾车、吸污车、清洗带吸污车、洒水车、消防洒水车、高压清洗车、冷藏车、厢式车等等。欢迎广大客户致电
Our company production and sales of various special vehicles: hook arm garbage truck, docking the garbage truck, compression garbage truck, fecal suction truck, swinging arm garbage truck, sewage suction truck, cleaning with a suction sewage truck, sprinkler, fire sprinkler, the high-pressure cleaning the car, refrigerator car, van, and so on. Welcome customers to call